Published since 1923
DOI: 10.33622/0869-7019
Russian Science Citation Index (RSCI) на платформе Web of Science


  • BASES AND FOUNDATIONS, UNDERGROUND STRUCTURES
  • Injection Technologies For Fixing Soil Bases During Construction And Reconstruction Of Underground Structures
  • UDC 624.159.1
    doi: 10.33622/0869-7019.2025.09.45-55
    Armen Z. TER-MARTIROSYAN, gic-mgsu@mail.ru
    Georgiy O. ANZHELO
    Vyacheslav A. ALEKSEEV, 634586@mail.ru
    Sofia I. BAZHENOVA
    National Research Moscow State University of Civil Engineering, Yaroslavskoye shosse, 26, Moscow 129337, Russian Federation
    Abstract. The development of industry and chemical technologies, combined with new innovative technologies, allows for the use of new methods to solve a wide range of emerging geotechnical problems. Traditional soil consolidation technologies in construction are also being optimized and made more efficient through the introduction of innovative technologies, upgraded equipment, and materials with a wide range of adjustable properties. Due to the specific features of cementation technologies, it is possible to improve various deformation characteristics of the soil massif under different injection impregnation modes and the possibility of using specific technical injection parameters for different types of soils. The article provides some examples of injection technologies for soil stabilization, soil consolidation to reduce settlement deformations, and the creation of anti-filtration curtains, and establishes general patterns that require adjustment of injection parameters. The article considers theoretical prerequisites in correlation with experimental data, proves the effectiveness of using cementation technology in the mode of injection impregnation, and establishes the general applicability of using these cementation methods to improve the technical characteristics of the cemented soils.
    Keywords: injection consolidation of soils, complex engineering and geological conditions, soil grouting, polymer compositions, tarring of soil, soil-concrete, soil stabilization, cuff technology
  • REFERENCES
    1. Jianjun She, Zihao Guo, Yilun Zhou. Research on scenario deduction and emergency decision-making evaluation for construction safety accidents [Исследование по разработке сценариев и оценке принятия экстренных решений в случае аварий, связанных с безопасностью строительства]. Reliability Engineering & System SafetyNovember, 2024, vol. 251, p. 110317.
    2. Jun long Peng, Xiao Liu. Analysis of factors influencing resource scheduling for emergency construction projects considering multiple spatial characteristics [Анализ факторов, влияющих на планирование ресурсов для аварийных строительных проектов, с учетом множества пространственных характеристик]. Developments in the Built Environment, 2024, vol. 17, p. 100329.
    3. Zhen Hu, Siyuan Li, Siyi Li. Literature review on construction safety resilience: a bibliometric analysis to map the state of the art [Обзор литературы по обеспечению безопасности строительства: библиометрический анализ, позволяющий составить представление о современном состоянии]. Safety and Health, 2025. doi: 10.1016/j.shaw.2025.05.004
    4. Belyi A., Karapetov E., Efimenko Y. Structural health and geotechnical monitoring during transport objects construction and maintenance (Saint-Petersburg example) [Техническое состояние конструкций и геотехнический мониторинг при строительстве и эксплуатации транспортных объектов (на примере Санкт-Петербурга)]. Procedia Engineering, 2017, vol. 189, pp. 145-151.
    5. Kulakov A. R., Akristiniy V. A. Scientific and technical support of unique high-altitude objects: assessment of technogenic and seismic hazards. Components of Scientific and Technological Progress, 2024, no. 12(102), pp. 53-56. (In Russ.).
    6. Kulakov A. R., Akristiniy V. A. Mechanisms for the application of information modelling technologies at individual stages of the life cycle of development projects [Механизмы применения технологий информационного моделирования на отдельных этапах жизненного цикла девелоперских проектов]. Real Estate: Economics, Management, 2023, no. 2, pp. 56-64.
    7. Shisterova A. V., Lapidus A. A. Scientific and technical support for the design of objects that do not have an increased level of responsibility [Научно-техническое сопровождение проектирования объектов, не имеющих повышенного уровня ответственности]. Materials of the I International Scientific and Practical Conference, 2019, pp. 27-33.
    8. Nezhnikova E. The use of underground city space for the construction of civil residential buildings [Использование подземного городского пространства для строительства гражданских жилых зданий]. Procedia Engineering, 2016, vol. 165, pp. 1300-1304.
    9. Volkov M. A., Petlenko S. A., Volkova D. O., Bazhenova I. S. Comparative analysis of compositions used to reinforce soils and foundations during reconstruction. Problems and Prospects in the International Transfer of Innovative Technologies. Collection of Articles from the International Scientific and Practical Conference. Ufa, 2021, pp. 40-44. (In Russ.).
    10. Bazhenova S. I., Alekseev V. A. Features of selecting the composition of fine-grained binders for injection. Stroitel'stvo i rekonstruktsiya, 2020, no. 3(89), pp. 99-108. (In Russ.).
    11. Alekseev V. Combined permeation grouting technologies using ultra microfine cement [Комбинированные технологии цементации с использованием ультрамикродисперсного цемента]. The Scientific Heritage, 2020, no. 481, pp. 3-4.
    12. Kochev D. Z., Alekseev S. V., Alekseev V. A. Features of engineering and geological surveys and experience in increasing the bearing capacity of contaminated soils in urban conditions in the Moscow region. Sergey's readings. Engineering geology and geoecology. Fundamental problems and applied tasks. Moscow, 2016, pp. 305-309. (In Russ.).
    13. Shlyakhova E., Serebryanaya I., Egorochkina, I., Matrosov A., Odinets M., Knyazhichenko M. Repair compositions for restoration of operated reinforced concrete structures [Ремонтные составы для восстановления эксплуатируемых железобетонных конструкций]. E3S Web of Conferences, 2021, no. 273(7), p. 04017.
    14. Bunov А. А., Dorozhinskiy V. B. Causes of collapse of the steel silo's load-bearing structures: design errors. Promyshlennoe i grazhdanskoe stroitel'stvo, 2019, no. 11, pp. 4-8. (In Russ.). doi: 10.33622/0869-7019.2019.11.04-08
    15. Gukova M. I., Farfel M. I., Iskendirov V. G. Design, manufacturing, and installation errors that lead to the emergency condition of building structures in industrial buildings and structures. Promyshlennoe i grazhdanskoe stroitel'stvo, 2013, no. 10, pp. 25-28. (In Russ.).
    16. Alekseev V. A., Harchenko A. I., Soloviev V. G., Nikonorov R. N. Sprayed concrete in mine construction. Vestnik MSSU, 2017, no. 7(106), pp. 780-787. (In Russ.).
    17. Wang Z.-F., Shen S.-L., Modoni G. Enhancing discharge of spoil to mitigate disturbance induced by horizontal jet grouting in clayey soil: Theoretical model and application [Усиление разгружающего грунта для уменьшения влияния, вызванного горизонтальной струйной цементацией в глинистом грунте: теоретическая модель и применение]. Computers and Geotechnics, 2019, vol. 111, pp. 222-228.
    18. Mahdi H., Tonon F. Ground reaction curve for tunnels with jet grouting umbrellas considering jet grouting hardening [Характеристики реакции грунта для туннелей с зонтичной струйной цементацией с учетом твердения при струйной цементации]. International Journal of Rock Mechanics and Mining Sciences, 2015, vol. 76, pp. 200-208.
    19. Makovetskiy O. A. Application of "jet grouting" for installation of substructures of estates [Применение cтруйной цементации для монтажа фундаментов жилых домов]. Procedia Engineering, 2016, vol. 150, pp. 2228-2231.
    20. Kashevarova G. G., Makovetskiy O. A. Analysis of experimental and estimated jet-grouted soil mass deformations [Анализ экспериментальных и расчетных деформаций грунтового массива при струйной цементации]. Ibid, pp. 2223-2227.
    21. Gьllь H. On the viscous behavior of cement mixtures with clay, sand, lime and bottom ash for jet grouting [О характеристиках вязкости цементных смесей с глиной, песком, известью и зольным остатком для струйной цементации]. Construction and Building Materials, 2015, vol. 93, pp. 891-910.
    22. Gьllь H. A new prediction method for the rheological behavior of grout with bottom ash for jet grouting columns [Новый метод прогнозирования реологических свойств раствора с зольным остатком для грунтоцементных колонн по технологии струйной цементации]. Soils and Foundations, 2017, vol. 57, iss. 3, pp. 384-396.
    23. Cristelo N., Soares E., Rosa I., Miranda T., Chaves A. Rheological properties of alkaline activated fly ash used in jet grouting applications [Реологические свойства смесей на основе зольных композиций, активированных щелочами, для технологии струйной цементации]. Construction and Building Materials, 2013, vol. 48, pp. 925-933.
    24. Thomas R., Gebregziabihe В.S., Giffin A., Peethamparan S. Micromechanical properties of alkali-activated slag cement binders [Реологические свойства золы-уноса, активированной щелочью для цементационных растворов]. Cement and Concrete Composites, 2018, vol. 90, pp. 241-256.
    25. Shi Z., Shi C., Wan S. et al. Effect of alkali dosage and silicate modulus on carbonation of alkali-activated slag mortars [Влияние дозировки щелочи и силикатного модуля на карбонизацию шлаковых растворов, активированных щелочью]. Cement and Concrete Research, 2018, vol. 113, pp. 55-64.
    26. Rahimova N. R., Rahimov R. Z. Development and promising opportunities for obtaining and using alkaline-activated hydraulic binders and materials based on them. Bulletin of the Volga Regional Branch of the Russian Academy of Architecture and Construction Sciences, 2011, no. 14, pp. 151-167. (In Russ.).
    27. Murtazaev S. A. Ju., Saydumov M. S., Murtazaeva T. S. A., Abusalimov A. S. The effect of finely ground mineral fillers of technogenic origin (MNTP) on the sedimentation of cement suspensions. Nauka i innovatsii v stroitel'stve [Science and Innovations in Construction]. Collection of Reports of the IV International Scientific and Practical Conference. Belgorod, 2020, pp. 372-379. (In Russ.).
    28. Murtazaev S. A. Ju., Salamanova M. Sh., Saydumov M. S., Hubaev M. S. The role of a finely ground technogenic filler in the formulation of filled binders for high-quality concretes. Millionshchikov-2020. Materials of the III All-Russian scientific and practical conference, dedicated to the 100th anniversary of the GGNTU named after academician M. D. Millionshchikov. Groznyy, 2020, pp. 226-233. (In Russ.).
    29. Broyd I. I. Struynaya geotekhnologiya [Jet geotehnology]. Moscow, ASV Publ., 2004. 440 p. (In Russ.).
    30. Malinin A. G. Influence of jet grouting modes on the diameter of soil-cement columns. Metro i tonneli , 2013, no. 4, p. 30. (In Russ.).
    31. Gьllь H., Cevik A., Al-Ezzi K. M. A., Gьlsan M. E. On the rheology of using geopolymer for grouting: A comparative study with cement-based grout included fly ash and cold bonded fly ash [О реологических свойствах использования геополимера для цементации: Сравнительное исследование с цементным раствором с золой-уноса и золой-уноса холодного связывания]. Construction and Building Materials, 2019, vol. 196, pp. 594-610.
    32. Ter-Martirosyan Z. G., Strunin P. V. Reinforcement of weak soils at the base of foundation slabs using soil jet grouting technology. Vestnik MGSU, 2010, № 4-2. pp. 310-315. (In Russ.).
    33. Ochmaсski M., Modoni G., Bzуwka J. Prediction of the diameter of jet grouting columns with artificial neural networks [Прогнозирование диаметра грунтоцементных колонн с помощью искусственных нейронных сетей]. Soils and Foundations, 2015, vol. 55, iss. 2, pp. 425-436.
    34. Ibragimov, M. N., Semkin V. V., Shaposhnikov A. V. Soil Solidification by Micro-Cements [Упрочнение грунтов микроцеметами]. Soil Mechanics and Foundation Engineering, 2017, vol. 53, no. 6, pp. 412-419.
    35. Jeong Y., Kang S.-H., Du Y., Moon J. Local Ca-structure variation and microstructural characteristics on one-part activated slag system with various activators [Локальные изменения Са-структуры и микроструктурных характеристик в однокомпонентной системе активированного шлака с различными активаторами]. Cement and Concrete Composites, 2019. doi: 10.1016/j.cemconcomp.2019.04.009
    36. Rumyantseva V. E., Konovalova V. S., Narmaniya B. E. Changes in the structural and phase composition and strength characteristics of concrete during liquid corrosion in chloridecontaining media [Изменение структурно-фазового состава и прочностных характеристик бетона при жидкостной коррозии в хлорсодержащих средах]. Journal of Physics: Conference Series, 2021, vol. 1926, p. 012057.
    37. Farfan J., Fasihi M., Breyer C. Trends in the global cement industry and opportunities for long-term sustainable CCU potential for Power-to-X [Тенденции в мировой цементной промышленности и возможности для долгосрочного устойчивого использования потенциала возобновляемых энергоисточников]. Journal of Cleaner Production, 2019, vol. 217, pp. 821-835.
    38. Song D., Lin L., Bao W. Exergy conversion efficiency analysis of a cement production chain [Анализ эффективности преобразования эксергии в цепочке производства цемента]. Energy Procedia, 2019, vol. 158, pp. 3814-3820.
    39. Elfaham M. M., Eldemerdas U. Advanced analyses of solid waste raw materials from cement plant using dual spectroscopy techniques towards co-processing [Расширенный анализ сырья из твердых отходов цементного завода с использованием методов двойной спектроскопии для совместной переработки]. Optics & Laser Technology, 2019, vol. 111, pp. 338-346.
    40. Salnikova A. S., Sheremet A. A., Salnikov D. A. Composite binder in construction. Mezhdunarodnaya nauchno-tekhnicheskaya konferentsiya molodykh uchenykh BGTU im. V. G. Shukhova [International scientific and technical conference of young scientists of BSTU named after V. G. Shukhov]. Belgorod, BSTU named after V.G. Shukhov, 2021, pp. 1031-1034. (In Russ.).
  • For citation: Ter-Martirosyan A. Z., Anzhelo G. O., Alekseev V. A., Bazhenova S. I. Injection Technologies for Fixing Soil Bases During Construction and Reconstruction of Underground Structures. Promyshlennoe i grazhdanskoe stroitel'stvo [Industrial and Civil Engineering], 2025, no. 9, pp. 45-55. (In Russ.). doi: 10.33622/0869-7019.2025.09.45-55

BACK